T4 Sliding Door Problems

The offside sliding door works ok but isn t operated.

T4 sliding door problems. Sliding door hinge for vw t4 1990 to 2003 44 95. Open the door go to the rear of the door you can see the lock mechanism. The lock button when unlocked door in the top holds the position. Then to tidy things up file the hole of any burrs and smear some paint on the exposed metal to prevent any rust issues.

Make sure you lube both above below the keep. If the sliding door on your van is hard to open and close or if it feels like the door of your van is stuck when you open and close it you can fix the stuc. Add to basket more info. In these cases the problem is usually that the rollers at the bottom of the door have started to rub against the track.

Sliding door hinge t4 nearside left 1990 2003. Most sliding doors have a mechanism called an adjusting screw located at the bottom of the door ends. It is just above the middle runner rail. The knob goes up and down when the central locking is operated but despite this it remains locked shut and can t be opened.

The problem started as soon as the temp started to drop on my drive back up north. Hello i ve a caravelle t4 2002. Now to offer up the contact and drill some pilot holes to attach the sliding door contact i then use some felt tip pin on the end of the contact and shut the door this transfers the mark across so i will no where i need to attach and repeat the drilling process. The actuation of the door handle back down fall which leads to a locking of all doors over the.

It was used in single digit temps this winter. Without intact spring the locking knob for light vibrations eg. Sliding door outer repair panel for vw t4 1990 to 2003 20 00. Add to basket more info.

It s the one with two sliding doors. I used t9 boeshield on the latch area and roller track. The problem went away and has not come back. The nearside sliding door has stopped working.

Add to basket more info. The rollers at the top can also wear down lowering the bottom of the door so that it rubs on the track. I had sliding door latch problems with the eurovan i recently purchased from the south west.